Patent Application
20220321087
A portion of the disclosure of this patent document contains material which is subject to copyright protection. This patent document may show and/or describe matter which is or may become trade dress of the owner. The copyright and trade dress owner has no objection to the facsimile reproduction by anyone of the patent disclosure as it appears in the Patent and Trademark Office patent files or records, but otherwise reserves all copyright and trade dress rights whatsoever.
This disclosure relates to radio frequency filters using acoustic wave resonators, and specifically to filters for use in communications equipment.
A radio frequency (RF) filter is a two-port device configured to pass some frequencies and to stop other frequencies, where “pass” means transmit with relatively low signal loss and “stop” means block or substantially attenuate. The range of frequencies passed by a filter is referred to as the “pass-band” of the filter. The range of frequencies stopped by such a filter is referred to as the “stop-band” of the filter. A typical RF filter has at least one pass-band and at least one stop-band. Specific requirements on a passband or stop-band depend on the specific application. For example, a “pass-band” may be defined as a frequency range where the insertion loss of a filter is better than a defined value such as 1 dB, 2 dB, or 3 dB. A “stop-band” may be defined as a frequency range where the rejection of a filter is greater than a defined value such as 20 dB, 30 dB, 40 dB, or greater depending on application.
RF filters are used in communications systems where information is transmitted over wireless links. For example, RF filters may be found in the RF front-ends of cellular base stations, mobile telephone and computing devices, satellite transceivers and ground stations, IoT (Internet of Things) devices, laptop computers and tablets, fixed point radio links, and other communications systems. RF filters are also used in radar and electronic and information warfare systems.
RF filters typically require many design trade-offs to achieve, for each specific application, the best compromise between performance parameters such as insertion loss, rejection, isolation, power handling, linearity, size and cost. Specific design and manufacturing methods and enhancements can benefit simultaneously one or several of these requirements.
Performance enhancements to the RF filters in a wireless system can have broad impact to system performance. Improvements in RF filters can be leveraged to provide system performance improvements such as larger cell size, longer battery life, higher data rates, greater network capacity, lower cost, enhanced security, higher reliability, etc. These improvements can be realized at many levels of the wireless system both separately and in combination, for example at the RF module, RF transceiver, mobile or fixed sub-system, or network levels.
High performance RF filters for present communication systems commonly incorporate acoustic wave resonators including surface acoustic wave (SAW) resonators, bulk acoustic wave (BAW) resonators, film bulk acoustic wave resonators (FBAR), and other types of acoustic resonators. However, these existing technologies are not well-suited for use at the higher frequencies and bandwidths proposed for future communications networks.
The desire for wider communication channel bandwidths will inevitably lead to the use of higher frequency communications bands. Radio access technology for mobile telephone networks has been standardized by the 3GPP (3rd Generation Partnership Project). Radio access technology for 5th generation mobile networks is defined in the 5G NR (new radio) standard. The 5G NR standard defines several new communications bands. Two of these new communications bands are n77, which uses the frequency range from 3300 MHz to 4200 MHz, and n79, which uses the frequency range from 4400 MHz to 5000 MHz. Both band n77 and band n79 use time-division duplexing (TDD), such that a communications device operating in band n77 and/or band n79 use the same frequencies for both uplink and downlink transmissions. Bandpass filters for bands n77 and n79 must be capable of handling the transmit power of the communications device. WiFi bands at 5 GHz and 6 GHz also require high frequency and wide bandwidth. The 5G NR standard also defines millimeter wave communication bands with frequencies between 24.25 GHz and 40 GHz.
The Transversely-Excited Film Bulk Acoustic Resonator (XBAR) is an acoustic resonator structure for use in microwave filters. The XBAR is described in U.S. Pat. No. 10,491,291, titled TRANSVERSELY EXCITED FILM BULK ACOUSTIC RESONATOR. An XBAR resonator comprises an interdigital transducer (IDT) formed on a thin floating layer, or diaphragm, of a single-crystal piezoelectric material. The IDT includes a first set of parallel fingers, extending from a first busbar and a second set of parallel fingers extending from a second busbar. The first and second sets of parallel fingers are interleaved. A microwave signal applied to the IDT excites a shear primary acoustic wave in the piezoelectric diaphragm. XBAR resonators provide very high electromechanical coupling and high frequency capability. XBAR resonators may be used in a variety of RF filters including band-reject filters, band-pass filters, duplexers, and multiplexers. XBARs are well suited for use in filters for communications bands with frequencies above 3 GHz.
Throughout this description, elements appearing in figures are assigned three-digit or four-digit reference designators, where the two least significant digits are specific to the element and the one or two most significant digit is the figure number where the element is first introduced. An element that is not described in conjunction with a figure may be presumed to have the same characteristics and function as a previously-described element having the same reference designator or the same two least significant digits.
Description of Apparatus
The Transversely-Excited Film Bulk Acoustic Resonator (XBAR) is a new resonator structure for use in microwave filters. The XBAR is described in U.S. Pat. No. 10,491,291, titled TRANSVERSELY EXCITED FILM BULK ACOUSTIC RESONATOR, which is incorporated herein by reference in its totality. An XBAR resonator comprises a conductor pattern having an interdigital transducer (IDT) formed on a thin floating layer or diaphragm of a piezoelectric material. The IDT has two busbars which are each attached to a set of fingers and the two sets of fingers are interleaved on the diaphragm over a cavity formed in a substrate upon which the resonator is mounted. The diaphragm spans the cavity and may include front-side and/or back-side dielectric layers. A microwave signal applied to the IDT excites a shear primary acoustic wave in the piezoelectric diaphragm, such that the acoustic energy flows substantially normal to the surfaces of the layer, which is orthogonal or transverse to the direction of the electric field generated by the IDT. XBAR resonators provide very high electromechanical coupling and high frequency capability.
A piezoelectric membrane may be a part of a plate of single-crystal piezoelectric material that spans a cavity in the substrate. A piezoelectric diaphragm may be the membrane and may include the front-side and/or back-side dielectric layers. An XBAR resonator may be such a diaphragm or membrane with an interdigital transducer (IDT) formed on a diaphragm or membrane.
Bandpass filters commonly use a ladder filter circuit that includes one or more series resonator connected in series between an input and an output of the filter and one or more shunt resonators, each connected between ground and one of the input, the output, or a node between two series resonators. The resonance frequencies of the shunt resonators are lower than the resonance frequencies of the series resonators. Often, the resonance frequencies of the shunt resonators are located below a lower edge of a passband of the filter and the antiresonance frequencies of series resonators are located above an upper edge of the passband.
Conventional XBAR resonators use a thin piezoelectric diaphragm spanning a cavity in a substrate; the diaphragm is fragile and may distort and/or deform with varying temperature. For example, the planar shape of the diaphragm may deform by forming bumps and troughs (e.g., a ruffled potato chip cross-sectional shape) due to thermal expansion when it exceeds a certain temperature. To avoid such deformation, the diaphragm may be supported with pedestals reaching to the substrate, but large acoustic loses from the diaphragm, through the pedestals and to the substrate must be reduced or eliminated.
Diaphragm distortion is not a problem in solidly-mounted XBARs where the piezoelectric plate is supported by a blanket layered Bragg reflector and thus does not have a cavity. An acoustic Bragg reflector reflects shear acoustic waves produced by the diaphragm to keep the acoustic energy predominantly confined to the diaphragm, such as from being absorbed by the substrate.
However, the blanket layered Bragg reflector requires a high impedance ratio between reflective layers and fully dielectric layers, with at least one of them having low dielectric permittivity. Some material layer combinations satisfying these conditions are SiO2/Diamond and SiOC/Si3N4. These combinations are not necessarily practical because processes for forming thin, precisely-controlled films of either diamond or SiOC are not currently available.
Described herein are devices having and methods of forming XBARs with solidly mounted resonator (SMR) pedestals supporting the piezoelectric membrane (e.g., diaphragm) of the XBARs. Embodiments presented here include an acoustic Bragg reflector sandwiched between the substrate and a back surface of the piezoelectric diaphragm, where the acoustic Bragg reflector configured to reflect shear acoustic waves at a resonance frequency of the acoustic resonator device. Two or four layers of the acoustic Bragg reflector form SMR pedestals that are attached to and support the back surface of the piezoelectric plate opposite some or all interleaved fingers of the IDT. The pedestals support the back surface of the piezoelectric diaphragm and the piezoelectric diaphragm only spans the spaces between adjacent pedestals and IDT fingers, guaranteeing an increased rigidity of the XBAR structure. The increased support and/or rigidity decreases distortion and/or deformation of the diaphragm with varying temperature, while still providing high electromechanical coupling (e.g., a high ratio of conversion of electrical energy to acoustic energy) and high frequency capability. The Pedestals further provide a path for thermal cooling of the XBAR in combination with thick A1 IDT electrodes (used in high power XBARs). In addition, to the pedestals providing mechanical support for the very thin diaphragm, they may provide a thermally conductive path for heat to flow from the diaphragm and IDT electrodes to the substrate.
The XBAR 100 is made up of a thin film conductor pattern formed on a surface of a piezoelectric plate 110 having parallel front and back surfaces 112, 114, respectively. The piezoelectric plate 110 is a thin single-crystal layer of a piezoelectric material such as lithium niobate, lithium tantalate, lanthanum gallium silicate, gallium nitride, or aluminum nitride. The piezoelectric plate is cut such that the orientation of the X, Y, and Z crystalline axes with respect to the front and back surfaces is known and consistent. In the examples presented, the piezoelectric plates may be Z-cut, which is to say the Z axis is normal to the surfaces. However, XBARs may be fabricated on piezoelectric plates with other crystallographic orientations.
The back surface 114 of the piezoelectric plate 110 is attached to a substrate 120 that provides mechanical support to the piezoelectric plate 110. The substrate 120 may be, for example, silicon, sapphire, quartz, or some other material. The substrate may have layers of silicon thermal oxide (TOX), SiO2, Diamond, SiOC, Si3N4, Tungsten (W) and crystalline silicon. The back surface 114 of the piezoelectric plate 110 or a diaphragm 115 including the plate may be bonded to the substrate 120 using a wafer bonding process, or grown on the substrate 120, or attached to the substrate in some other manner. The piezoelectric plate may be attached directly to the substrate or may be attached to the substrate via one or more intermediate material layers.
The conductor pattern of the XBAR 100 includes an interdigital transducer (IDT) 130. The IDT 130 includes a first plurality of parallel fingers, such as finger 136, extending from a first busbar 132 and a second plurality of fingers extending from a second busbar 134. The first and second pluralities of parallel fingers are interleaved. The interleaved fingers overlap for a distance AP, commonly referred to as the “aperture” of the IDT. The center-to-center distance L between the outermost fingers of the IDT 130 is the “length” of the IDT.
The first and second busbars 132, 134 serve as the terminals of the XBAR 100. A radio frequency or microwave signal applied between the two busbars 132, 134 of the IDT 130 excites a primary acoustic mode within the piezoelectric plate 110. As will be discussed in further detail, the excited primary acoustic mode is a bulk shear mode where acoustic energy propagates along a direction substantially orthogonal to the surface of the piezoelectric plate 110, which is also normal, or transverse, to the direction of the electric field created by the IDT fingers. Thus, the XBAR is considered a transversely-excited film bulk wave resonator.
A cavity 140 is formed in the substrate 120 such that a portion 115 of the piezoelectric plate 110 containing the IDT 130 is suspended over the cavity 140 without contacting the substrate 120. SMR pedestals 158 that are part of an acoustic Bragg reflector 154 formed in the cavity 140 are attached to the diaphragm 115 at locations under where the first and second plurality of parallel fingers 136 are disposed, to support plate 110.
“Cavity” has its conventional meaning of “an empty space within a solid body.” The cavity 140 may be a hole completely through the substrate 120 (as shown in Section A-A and Section B-B) or a recess in the substrate 120 (as shown subsequently in
In some cases, the Bragg reflector 154 and SMR pedestals 158 may be formed by forming layers of the Bragg reflector on a second substrate 121 and then attaching the second substrate to the bottom of substrate 120 such that the reflector and pedestals stick up through the bottom of the cavity 140 such as shown in section A-A. The layers of the Bragg reflector may be formed by blanket layering the reflector layers across a top surface of the second substrate 121, masking over the pedestal locations; and performing one or more selective etches to remove one or more top layers of the Bragg reflector between the pedestals. In another case, an etch stop layer may be deposited below a number of top layers of the reflector to select where a pedestal portion 156 having pedestals 158 will end and a mirror portion 155 having layers of the reflector across the cavity will begin. Then, the top layers of the reflector are etched to the etch stop to form the pedestals.
In other cases, instead of etching, a lift-off process may be used to remove the layers between the pedestals. For example, the layers of the mirror portion 155 may be deposited in sequence. A lift-off photoresist mask may be formed at the top of mirror portion 155 and between the pedestal locations. The top layers of the Bragg reflector may then be deposited. Removing the photoresist mask lifts off the top layers of the Bragg reflector between the pedestals to form pedestal portion 156.
Areas of the Bragg reflector that extend laterally beyond the cavity perimeter 145 and that are not going to extend vertically into cavity 140 can be etched away before, during or after forming the pedestals. Attaching the two substates will be done so that the SMR pedestals 158 are attached to the bottom surface of diaphragm 115 or back surface 114 at locations under where the fingers 136 are disposed.
As shown in
The portion 115 of the piezoelectric plate suspended over the cavity 140 will be referred to herein as the “diaphragm” 115 (for lack of a better term) due to its physical resemblance to the diaphragm of a microphone. The diaphragm 115 may be continuously and seamlessly connected to the rest of the piezoelectric plate 110 around all, or nearly all, of perimeter 145 of the cavity 140. In this context, “contiguous” means “continuously connected without any intervening item”. The IDT 130 is positioned on the piezoelectric plate 110 such that at least the fingers 136 of the IDT 130 are disposed on the diaphragm 115 of the piezoelectric plate that spans, or is suspended over, the cavity 140.
For ease of presentation in
A front-side dielectric layer 214 may optionally be formed on the front side of the piezoelectric plate 110. The “front side” of the XBAR is, by definition, the surface facing away from the substrate. The front-side dielectric layer 214 has a thickness tfd. The front-side dielectric layer 214 is formed between the IDT fingers 236. Although not shown in
SMR pedestals 158 of a Bragg reflector may be attached to plate 110 or back-side dielectric layer 216 (when it exists) at locations under where fingers 236 are disposed, such as to support diaphragm 115 over cavity 140.
The front side dielectric layer 214 may be formed over the IDTs of some (e.g., selected ones) of the XBAR devices in a filter. The front side dielectric 214 may be formed between and cover the IDT finger of some XBAR devices but not be formed on other XBAR devices. For example, a front side frequency-setting dielectric layer may be formed over the IDTs of shunt resonators to lower the resonance frequencies of the shunt resonators with respect to the resonance frequencies of series resonators, which have thinner or no front side dielectric. Some filters may include two or more different thicknesses of front side dielectric over various resonators. The resonance frequency of the resonators can be set thus “tuning” the resonator, at least in part, by selecting a thicknesses of the front side dielectric layer.
Further, a passivation layer may be formed over the total surface of the XBAR device 100 except for contact pads where electric connections are made to circuitry external to the XBAR device. The passivation layer is a thin dielectric layer intended to seal and protect the surfaces of the XBAR device while the XBAR device is incorporated into a package. The front side dielectric layer and/or the passivation layer may be, SiO2, Si3N4, Al2O3, some other dielectric material, or a combination of these materials.
The thickness of the passivation layer may be selected to protect the piezoelectric plate and the metal electrodes from water and chemical corrosion, particularly for power durability purposes. It may range from 10 to 100 nm. The passivation material may consist of one or more oxide and/or nitride coatings such as SiO2 and Si3N4 material.
The IDT fingers 236 may be one or more layers of aluminum or a substantially aluminum alloy, copper or a substantially copper alloy, beryllium, tungsten, molybdenum, gold, or some other conductive material. Thin (relative to the total thickness of the conductors) layers of other metals, such as chromium or titanium, may be formed under and/or over the fingers to improve adhesion between the fingers and the piezoelectric plate 110 and/or to passivate or encapsulate the fingers. The busbars (132, 134 in
Dimension p is the center-to-center spacing or “pitch” of the IDT fingers, which may be referred to as the pitch of the IDT and/or the pitch of the XBAR. Dimension w is the width or “mark” of the IDT fingers. The IDT of an XBAR differs substantially from the IDTs used in surface acoustic wave (SAW) resonators. In a SAW resonator, the pitch of the IDT is one-half of the acoustic wavelength at the resonance frequency. Additionally, the mark-to-pitch ratio of a SAW resonator IDT is typically close to 0.5 (i.e. the mark or finger width is about one-fourth of the acoustic wavelength at resonance). In an XBAR, the pitch p of the IDT is typically 2 to 20 times the width w of the fingers. In addition, the pitch p of the IDT is typically 2 to 20 times the thickness is of the piezoelectric slab 212. The width of the IDT fingers in an XBAR is not constrained to one-fourth of the acoustic wavelength at resonance. For example, the width w of XBAR IDT fingers may be 500 nm or greater, such that the IDT can be fabricated using optical lithography. The thickness tm of the IDT fingers may be from 100 nm to about equal to the width w. The thickness of the busbars (132, 134 in
Thus, substrate 320 has a substrate top surface 350 and a cavity bottom surface 352 below that forms the bottom of cavity 340. Acoustic Bragg reflector 354 is sandwiched between the substrate cavity bottom surface 352 and a back surface of the piezoelectric diaphragm 315. The acoustic Bragg reflector is configured to reflect shear acoustic waves at a resonance frequency of the acoustic resonator device 300. Two or more layers of the acoustic Bragg reflector form SMR pedestals 358 that support the back surface of the piezoelectric diaphragm 315 opposite some or all interleaved fingers 336 of the IDT. For example, the SMR pedestals may be part of reflector 354 that is attached to diaphragm 315 at locations under where the fingers 336 are disposed on diaphragm 315.
The cavity 340 may be formed, for example, by etching the substrate 320 before attaching the piezoelectric plate 310. This type of cavity 340 may be as swimming pool cavity that does not extend to the bottom surface of the substrate. This type of cavity may be formed by masking and etching selected areas of the front surface of the substrate 320 to form both shunt and series cavities. It may also or independently involve selectively etching a sacrificial layer of material deposited in the cavity area locations and depths to form both shunt and series cavities.
The Bragg reflector 354 and SMR pedestals 358 may be formed after forming cavity 340; and before piezoelectric plate 110 and the substrate 120 are attached. The layers of the Bragg reflector may be formed by forming layers of the Bragg reflector on the substrate cavity bottom surface 352 in the cavity, masking over the pedestal locations, and performing one or more selective etches of the layers of pedestal portion 356 of the Bragg reflector with respect to the mask to remove one or more top layers of the Bragg reflector pedestal portion 356 between the pedestals 358. In another case, an etch stop layer may be deposited below a number of top layers of the reflector to select where a pedestal portion 356 having pedestals 358 will end and a mirror portion 355 having layers of the reflector across the cavity 340 will begin. Then, the top layers of the reflector are etched to the etch stop to form the pedestals.
In other cases, instead of etching, a lift-off process may be used to remove the layers between the pedestals 336. For example, the layers of the mirror portion 355 may be deposited in sequence. A lift-off photoresist mask may be formed at the top of mirror portion 355 and between the pedestal locations. The top layers of the Bragg reflector may then be deposited. Removing the photoresist mask lifts off the top layers of the Bragg reflector between the pedestals to form pedestal portion 356.
The plate 310 or diaphragm 315 may then be attached to or mounted onto substrate 320 so that the back surface of the piezoelectric diaphragm 315 is attached to or bonded to the top surfaces of the SMR pedestals 358, and the top surfaces of the SMR pedestals 358 are opposite some or all interleaved fingers 336 of the IDT.
In some cases, air gaps between the pedestals 358 of pedestal portion 356 may be filled with a sacrificial layer or material before bonding the plate to the substrate. The sacrificial layer may be Kapton, or phosphosilicate glass (PSG) material to be etched away at the end of processing through via hole openings 342 at the sides of the XBAR diaphragm 315.
The diaphragm 315 may be contiguous with the rest of the piezoelectric plate 310 around a large portion of a perimeter 345 of the cavity 340. For example, the diaphragm 315 may be contiguous with the rest of the piezoelectric plate 310 around at least 50% of the perimeter of the cavity 340.
One or more intermediate material layers 322 may be attached between plate 310 and substrate 320. An intermediary layer may be an etch stop layer, a sealing layer, an adhesive layer or layer of other material that is attached or bonded to plate 310 and substrate 320. In other embodiments, the piezoelectric plate 310 is attached directly to the substrate 320 and an intermediary layer does not exist.
In some cases, plate 310 is a single-crystal piezoelectric plate, a z-axis of the plate 310 is normal to the front and back surfaces of the plate, the IDT is oriented such that the fingers 336 of the IDT are parallel to an x-axis of the plate 310, and the plate 310 is one of lithium niobate and lithium tantalate.
While the cavity 340 is shown in cross-section, it should be understood that the lateral extent of the cavity is a continuous closed band area of substrate 320 that surrounds and defines the size of the cavity 340 in the direction normal to the plane of the drawing. The lateral (i.e. left-right as shown in the figure) extent of the cavity 340 is defined by the lateral edges substrate 320. The vertical (i.e. down from plate 310 as shown in the figure) extent or depth of the cavity 340 into substrate 320. In this case, the cavity 340 has a side cross-section rectangular, or nearly rectangular, cross section.
The XBAR 300 shown in
An acoustic resonator based on shear acoustic wave resonances can achieve better performance than current state-of-the art film-bulk-acoustic-resonators (FBAR) and solidly-mounted-resonator bulk-acoustic-wave (SMR BAW) devices where the electric field is applied in the thickness direction. In such devices, the acoustic mode is compressive with atomic motions and the direction of acoustic energy flow in the thickness direction. In addition, the piezoelectric coupling for shear wave XBAR resonances can be high (>20%) compared to other acoustic resonators. High piezoelectric coupling enables the design and implementation of microwave and millimeter-wave filters with appreciable bandwidth.
SMR pedestals of a Bragg reflector (not shown in
Resonator 400 has substrate 420 having a cavity 440. Substrate 420 has substrate top surface 450 and cavity 440 has cavity top surface 452. A piezoelectric plate 410 (e.g., part of diaphragm 415) spans the cavity 440. Plate 410 has a plate front surface 411 and plate back surface 412 that is mounted on the substrate top surface 450 at the perimeter of cavity 440. The front and back surfaces of plate 410 may be a planarized (e.g., CMP or polished). A portion of the piezoelectric plate 410 that is not attached to substrate 420 forms diaphragm 415 that spans the cavity 440. The diaphragm 415 has a desired thickness for shunt or series resonators. In some cases, the thickness has a frontside dielectric (not shown) to form a shunt resonator. Interdigital transducer (IDT) 434 formed on a front surface 411 of the piezoelectric plate 410 such that interleaved fingers 436 of the IDT are disposed on the diaphragm 415. The cavity 440 may be a swimming pool cavity. It may be neither back etched nor front etched through the plate.
Acoustic Bragg reflector 454 is sandwiched between the substrate 420 and a back surface 412 of the piezoelectric plate 410. In some cases, reflector 454 is sandwiched between the substrate cavity bottom surface 452 and a back surface of the diaphragm 415 which may have a back-side dielectric and/or bonding layer. Two or more layers of the acoustic Bragg reflector 454 form SMR pedestals 458 that support the back surface 412 of the piezoelectric plate opposite some or all interleaved fingers 136. In some cases, the pedestals support every finger. In other cases, the pedestals support and are aligned with every n fingers of the IDT, where n is an integer greater than or equal to two and less than or equal to twenty. The pedestals may be periodically placed or placed in a pattern such as two, a space, then two more. Being aligned with may mean that the pedestals are centered under and extend along some or all of the length of each the fingers.
The term “sandwiched” means the acoustic Bragg reflector 454 is both disposed between and physically connected to a surface 452 of the substrate 220 and the back surface 412 of the piezoelectric plate 410. The acoustic Bragg reflector 454 includes multiple layers that alternate between materials having high acoustic impedance and materials have low acoustic impedance, thus creating a high impedance ration between adjacent layers of the reflector. “High” and “low” are relative terms. For each layer, the standard for comparison is the adjacent layers. Each “high” acoustic impedance layer has an acoustic impedance higher than that of both the adjacent low acoustic impedance layers. Each “low” acoustic impedance layer has an acoustic impedance lower than that of both the adjacent high acoustic impedance layers. Each of the layers has a thickness equal to, or about, one-fourth of the acoustic wavelength at or near a resonance frequency of the XBAR 400. Materials having comparatively low acoustic impedance include silicon dioxide, silicon oxycarbide, aluminum, and certain plastics such as cross-linked polyphenylene polymers. Materials having comparatively high acoustic impedance include silicon nitride, aluminum nitride, silicon carbide, and metals such as molybdenum, tungsten, gold, and platinum. All of the high acoustic impedance layers of the acoustic Bragg reflector 454 are not necessarily the same material, and all of the low acoustic impedance layers are not necessarily the same material. In the example of
An acoustic Bragg reflector may have more than, or less than, eight layers. The mirror portion may have more than, or less than, six layers and the pedestals portion may have more than, or less than, two layers. In some cases, the reflector has between 8 and 200 layers. It may have 16, 24, 32, 40, 60 or 80 layers. The mirror portion may have ¾ of and pedestal portion may have ¼ of the reflector layers. In another case, the mirror portion has ½ of and pedestal portion has ½ of the reflector layers.
The acoustic Bragg reflector 454 is configured to reflect shear acoustic waves at a resonance frequency of the acoustic resonator device 400. Two layers 422 and 424 of the acoustic Bragg reflector form SMR pedestals 458 that support the back surface of the piezoelectric diaphragm 415 opposite all of the interleaved fingers 436 of the IDT. In other cases, the pedestals 458 only support some of interleaved fingers 436 of the IDT, such as every other finger or every third finger. Where they exist, the SMR pedestals 458 are part of reflector 454 that is attached to diaphragm 415 at locations under where the fingers 436 are disposed on diaphragm 415. The plate 410 has thickness ts. The layer 422 has thickness tp1 of silicon dioxide-SiO2, and layer 424 has thickness tp2 of Tungsten-W.
In some cases, all of the resonators on the same chip have the same Bragg reflector. For example, all of the resonators on substrate 120, 320 or 420 may have the same chip Bragg reflector layer materials and thickness as reflectors 154, 354 or 454, respectively. In some cases, shunt and series resonators may be on different chips, in which case the Bragg reflectors may be different, such as by having one or more different materials or thicknesses on the different chips. In some cases, shunt and series resonators may be on different chips, in which case the Bragg reflectors may be different.
One or more intermediate material layers (not shown) may be attached between SMR pedestals 458 and diaphragm 415. Here, an intermediary layer may be an etch stop layer, a sealing layer, a bonding layer, an adhesive layer or layer of other material that is attached or bonded to plate 310 and substrate 320. The intermediate layer may only exist where the SMR pedestals 458 are or may cover the total bottom surface of the diaphragm 415. The intermediate layer maybe a bonding layer and/or a back-side dielectric layer of the diaphragm 415.
Being opposite the fingers may mean that the pedestal is centered under a width of and extends along a length of the finger. Each pedestal 458 may exist opposite the total width and total length of the finger 436 it is opposite of. In some cases, each pedestal 458 has a width extending beyond the total width of the finger 436 it is opposite of by between 1 and 10 percent of the total width of the finger. Each pedestal 458 may extend from the busbar that the opposing finger is attached to, along most or all of the length of the finger. In some cases, each pedestal 458 has a length extending only along a middle portion of a length of the finger it is opposed to, such as by between 5 and 20 percent of the total length of that finger. In some cases, each pedestal 458 has a length extending only along an end portion of the length of the finger it is opposed to, such as by between 5 and 20 percent of the total length of that finger.
Each pedestal 458 may also exist opposite the busbar attached to the finger the pedestal is opposite to. In some case, each pedestal 458 may also exist opposite the gap between the end of the finger it is opposite to and the adjacent busbar that it is not attached to. It may or may not touch the pedestal 458 of the adjacent busbar.
The plate 410 has thickness ts, one layer 422 of pedestal 458 has thickness tp1 of silicon dioxide-SiO2, and layer 424 of pedestal 458 has thickness tp2 of Tungsten-W. The acoustic Bragg reflector 454 also has three pair of layers 426 of SiO2 and 428 of W under the SMR pedestals 458. Each layer 426 and 428 may exist across the top view area of the cavity and to the perimeter of the cavity.
The topmost layer of these pairs of layers is attached to layer 424 and the bottommost layer of these pairs is attached to surface 452 of substrate 420. One or more intermediate material layers (not shown) may be attached between the bottommost layer of these pairs of layers and surface 452 of substrate 420, such as noted for intermediate material layers attached between SMR pedestals 458 and diaphragm 415. For example, a layer of SiO2 may between the lowest layer of tungsten of the reflector 454 and substrate 420.
Each of layer 426 has thickness tb1 of silicon dioxide-SiO2, and each of layer 428 has thickness tb2 of Tungsten-W. Thickness tb1 may be equal to thickness tp1, and thickness tb2 may be equal to thickness tp2. Tp1 may be between 150 and 230 nm and tp2 may be between 110 and 180 nm. Tb1 may be equal to tp1 and tb2 may be equal to tp2.
Pairs of layers 426 and 428 of the acoustic Bragg reflector 454 are configured to reflect shear acoustic waves at a resonance frequency of the XBAR resonator 400. Layers 422 and 424 of the SMR pedestals 458 are also configured to reflect shear acoustic waves at a resonance frequency of the XBAR resonator 400.
In Example 1, tp1 and tb1 are 190 nm; and tp2 and tb2 are 145 nm. Here, fingers 436 are aluminum (Al) with thickness (e.g., tm) of 500 nm and the substrate 420 is a silicon (Si) base substrate. The mark-to-pitch is 0.3 for the fingers 436 and for the pedestals 458. The pitch of the fingers 436 is 3.9 um. Plate 410 may be 400 nm thick of Z-Y cut lithium niobate (LN) or 400 nm thick of 120 degree cut Y-X cut lithium niobate (LN). The 120 degree cut refers to the cut angle of the Y-X cut LN in degrees. The example may have electrical boundary conditions where each of the layers 424 and 428 has a floating electrical potential. In another case, each of the layers 428 has a floating electrical potential and each of layers 424 has a potential equal to that of the corresponding A1 finger 436 that is opposite of the layer 424.
The W layer 424 in the pedestal has a floating potential when the metal layer 424 in the pedestal 458 is not electrically connected to any other electrode, such as by not being electrically connected to a busbar or IDT. The floating potential of layer 424 is formed through a capacitive coupling through the LN plate 410, the oxide layer 422 in pedestal 458 and the first oxide layer 426 in the continuous Bragg mirror portion 455. The bottom of this first SiO2 layer 426 has floating potential throughout the device. It may be a common or ground electrode for the two composite capacitances formed by neighboring electrodes.
Alternatively, the W layer 424 in the pedestal has a potential equal to that of the corresponding A1 finger 436 when the metal layer 424 in the pedestal 458 is electrically connected to a corresponding top electrode, such as to a busbar or IDT. This connection can by a via through the LN/SiO2 plate and bonding layer outside the pedestal domain or perimeter 415 (e.g., outside the device active area) from the IDT to the layer 424. In practice every other or second electrode of a filter (e.g., filter 500) can be connected to one pad that can be via connected to corresponding metal layer(s) under the LN plate 41. This applies separately to odd and even strips. One can imagine a bottom IDT configuration (formed by the top metal layer 424 in the pedestal) with two feeding pads, each connected to the true (e.g., having opposing fingers) IDT pad or busbar of IDT 130 on top.
Graph 460 shows a plot 461 of admittance in dB and a plot 462 of conductance for Example 1 having plate 410 that is a 400 nm thick of Z-Y cut lithium niobate (LN) plate. Graph 465 shows a plot 466 of admittance in dB and a plot 467 of conductance for Example 1 having plate 410 that is a 400 nm thick of 120 degree cut Y-X cut lithium niobate (LN) plate. In graphs 460 and 465, each of layers 424 and 428 has a floating electrical potential.
The admittance plot 461 for the simulated XBAR 400 exhibits a resonance 463 at a frequency FR of 4665 MHz and an anti-resonance 464 at a frequency FAR of 5110 MHz. Thus, the resonance to antiresonance (R-μ-R) for plot 461 is 8.1 percent. The admittance plot 466 for the simulated XBAR 400 exhibits a resonance 468 at a frequency FR of 4650 MHz and an anti-resonance 469 at a frequency FAR of 5195 MHz. Thus, the resonance to antiresonance (R-a-R) for plot 466 is 11.1 percent.
The better performance of the graph 465 as compared to graph 460 is primarily due to greater electromechanical coupling of the 400 nm thick of 120 degree cut Y-X cut lithium niobate (LN) plate version of plate 410 as compared to that of the 400 nm thick of Z-Y cut lithium niobate (LN) plate version of plate 410 to the top of reflector 454. That is, the graph 465 shows higher electromechanical coupling (i.e. and thus a greater difference between resonance frequency 468 and anti-resonance frequency 469 than those of frequencies 463 and 464) because graph 465 is for a plate that has 120-degree Y-X cut LN instead of the Z-Y cut LN. The graph 460 is Z-Y cut LN which inherently has lower coupling. The lower electromechanical coupling of the 400 nm thick of Z-Y cut lithium niobate (LN) plate is due to less amount of electric energy in the IDT being transformed to acoustic energy in plate 410 via the piezoeffect for the Z-Y cut as compared to for the 120-degree Y-X cut LN plate. Once the acoustic part of the energy appears, its propagation may be defined by the elastic properties of the plate material. The acoustic emission of the two resonators may be fixed by the Bragg stack to be the same for both XBARs. Thus, the plate version for graph 465 may be more desirable than that for graph 460.
For
The better performance (i.e. the higher R-a-R) of the plots 466 and 467 as compared to plots 471 and 472 is primarily due to greater electromechanical coupling of the floating potential W layers 424 and 428 version of reflector 454 to plate 410 than that of the XBAR 400 version with layers 424 having a biased electrical potential. One reason is that extra parasitic capacitance is formed between the pedestals having the biased electrical potential layers 424 through the underlying Bragg Stack of mirror portion 455. The extra parasitic capacitance adds a component to the electric energy in the system, while acoustic energy remains the same. Thus, the ratio between acoustic and electric energies in the system becomes smaller and therefore the coupling is smaller for plots 471 and 472. Thus, the devices and potential versions for plots 466 and 467 is more desirable than those for plots 471 and 472.
A difference between resonator 480 and 400 is that resonator 480 has an acoustic Bragg reflector 484 instead of reflector 454 sandwiched between the substrate 420 and a back surface 412 of the piezoelectric plate 410. Reflector 484 may be sandwiched between the substrate cavity bottom surface 452 and a back surface of the diaphragm 415 which may have a back-side dielectric and/or bonding layer. Four or more layers of the acoustic Bragg reflector 484 form SMR pedestals 488 that support the back surface 412 of the piezoelectric plate opposite some or all interleaved fingers 436. In some cases, the pedestals 488 are aligned with, support fingers of and/or are placed in a pattern as noted for pedestals 458 of reflector 454.
In the example of
The acoustic Bragg reflector 484 is configured to reflect shear acoustic waves at a resonance frequency of the resonator 480. Four layers 422 and 424 of the reflector form SMR pedestals 488 that are attached to diaphragm 415 and support the back surface of the piezoelectric diaphragm 415 opposite all or some of the interleaved fingers 436 as noted for fingers 454. Being opposite the fingers may mean that the pedestal is centered under and/or extends along the length of the finger as noted for pedestals 454.
One or more intermediate material layers (not shown) may be attached between SMR pedestals 488 and diaphragm 415 as noted for reflector 454. The plate 410 has thickness ts. The layers 422, 424, 426 and 428 have thicknesses as note for reflector 454. The pedestals of reflector 484 may be opposite the fingers, busbars and opposing busbars of XBAR 480 as described reflector 454 and XBAR 400.
The plate 410 has thickness ts, two interleaved layers 422 have thickness tp1 of silicon dioxide-SiO2, and layers 424 have thickness tp2 of Tungsten-W as noted for reflector 454. The acoustic Bragg reflector 484 has two pair of layers 426 of SiO2 and 428 of W under the SMR pedestals 488. Each layer 426 and 428 may exist across the top view area of the cavity and to the perimeter of the cavity. The topmost layer of these pairs of layers is attached to bottommost layer 424 and the bottommost layer of these pairs is attached to surface 452 of substrate 420. One or more intermediate material layers may be attached between the bottommost layer of these pairs of layers and surface 452 of substrate 420 as noted for SMR pedestals 458 and diaphragm 415.
For reflector 484, each layer 426 has thickness tb1 of silicon dioxide-SiO2, and each of layer 428 has thickness tb2 of Tungsten-W as noted for layers 426 and 428 of reflector 454. Pairs of layers 426 and 428 and of layer 422 and 424 are configured to reflect shear acoustic waves at a resonance frequency of the XBAR resonator 480 as noted for these layers of reflector 454.
Example 2 is Example 1 as applied to XBAR 480 instead of XAR 400; and uses plate 410 of 400 nm thick of 120 degree cut Y-X cut lithium niobate (LN).
For
The better performance of the plots 491 and 492 as compared to plots 466 and 467 is primarily due to greater electromechanical coupling of the floating potential W layers 424 and 428 version of reflector 484 to plate 410 than that of the XBAR 400 version with layers 424 and 428 of reflector 454. One reason is that extra parasitic capacitance is formed between the pedestals having only the two layers 422 and 424 in the pedestals 458 than the lower parasitic capacitance of reflector 484 which has four layers 422 and 424 in the pedestals 488 and thus has parasitic capacitance that is two times lower than that of reflector 454. The structure with 4 layers in pedestal has smaller parasitic capacitance than the structure with 2 layers since in the structure with 4 layers there are 2 capacitors connected in series; i.e., with effectively half capacitance to the one formed in 2 layer pedestal. Thus, the reduction in parasitic capacitance leads to overall decrease in electric energy in the system for the same acoustic energy-thus the coupling which is their ratio (mechanical/acoustic vs. electrical energy) becomes larger. Thus, the reflector 480 for graph 491 and 492 may be more desirable than reflector 400 for graph 466 and 467.
A difference between resonator 490 and 400 or 480 is that resonator 490 has an acoustic Bragg reflector 494 instead of reflector 454 or 484, respectively, sandwiched between the substrate 420 and a back surface 412 of the piezoelectric plate 410. Reflector 494 may be sandwiched between the substrate cavity bottom surface 452 and a back surface of the diaphragm 415 which may have a back-side dielectric and/or bonding layer. Eight or more layers of the acoustic Bragg reflector 494 form SMR pedestals 498 that support the back surface 412 of the piezoelectric plate opposite some or all interleaved fingers 436. In some cases, the pedestals 498 are aligned with, support fingers of and/or are placed in a pattern as noted for pedestals 458 of reflector 454.
In the example of
The acoustic Bragg reflector 494 is configured to reflect shear acoustic waves at a resonance frequency of the resonator 490. Eight layers 422 and 424 of the reflector form SMR pedestals 498 that are attached to diaphragm 415 and support the back surface of the piezoelectric diaphragm 415 opposite all or some of the interleaved fingers 436 as noted for fingers 454. Being opposite the fingers may mean that the pedestal is centered under and/or extends along the length of the finger as noted for pedestals 454.
One or more intermediate material layers (not shown) may be attached between SMR pedestals 498 and diaphragm 415 as noted for reflector 454. The plate 410 has thickness ts. The layers 422 and 424 have thicknesses as note for reflector 454. The pedestals of reflector 494 may be opposite the fingers, busbars and opposing busbars of XBAR 480 as described reflector 454 and XBAR 400.
The plate 410 has thickness ts, two interleaved layers 422 have thickness tp1 of silicon dioxide-SiO2, and layers 424 have thickness tp2 of Tungsten-W as noted for reflector 454. The bottommost layer of these pairs is attached to surface 452 of substrate 420. One or more intermediate material layers may be attached between the bottommost layer of these pairs of layers and surface 452 of substrate 420 as noted for SMR pedestals 458 and diaphragm 415.
Pairs of layers 422 and 424 are configured to reflect shear acoustic waves at a resonance frequency of the XBAR resonator 490 as noted for these layers of reflector 454.
A difference between resonator 499 and 400 is that resonator 499 has an acoustic Bragg reflector 444 instead of reflector 454 sandwiched between the substrate 420 and a back surface 412 of the piezoelectric plate 410.
Reflector 444 may be similar to reflector 454, except that reflector 444 also has layers 422, 424, 426 and 428 sandwiched between the substrate cavity bottom surface 452 and a back surface of the diaphragm 415 around the perimeter 145 of cavity 440. Reflector 444 may have layers 422, 424, 426 and 428 extending in as blanket layers between substrate cavity bottom surface 452 and a back surface of the diaphragm 415, except for the pedestal portion 446 where layers 422 and 424 are removed to form the pedestals 458 and thus to also form cavity 440.
In the example of
The plate 410 or diaphragm 415 may be attached to or mounted onto the reflector 444 so that the back surface of the piezoelectric diaphragm 4158 is attached to or bonded to the top surfaces of the perimeter 145 and pedestals 458, and the top surfaces of the pedestals are opposite locations of some or all interleaved fingers.
The acoustic Bragg reflector 444 is configured to reflect shear acoustic waves at a resonance frequency of the resonator 499 similar to reflector 454 and resonator 400.
The layers of the Bragg reflector 444 may be formed by blanket layering the reflector layers across a top surface 452 of the substrate 420, masking over the pedestal locations, performing a first selective etch with respect to the mask to remove a top layer 422 of the Bragg reflector between the pedestals, and then performing a second selective etch with respect to the mask to remove a second top layer 424 of the Bragg reflector between the pedestals.
In another case, an etch stop layer may be deposited below a selected number of top layers, such as below layer 424 of the reflector to select where the pedestal portion 446 will end and mirror portion 445 of the reflector will begin. Then, the top two layers of the reflector are etched to the etch stop to form the pedestals.
In other cases, instead of etching, a lift-off process may be used to remove the layers between the pedestals 458. For example, the layers of the mirror portion 455 may be deposited in sequence. A lift-off photoresist mask may be formed at the top of mirror portion 455 and between the pedestal locations. The top layers 422 and 424 of the Bragg reflector may then be deposited. Removing the photoresist mask lifts off the top layers 422 and 424 of the Bragg reflector between the pedestals 458 to form pedestal portion 456.
The plate 410 or diaphragm 415 is then be attached to or mounted onto substrate 420 so that the back surface of the piezoelectric diaphragm 415 is attached to or bonded to the top surfaces of the SMR pedestals 458, and the top surfaces of the SMR pedestals 458 are opposite some or all interleaved fingers 436 of the IDT.
The concepts described above for resonator 499 can also be applied to resonators 480 and 490. For example, resonator 480 or 490 can have a version of a reflector 484 or 494, respectively, that also has layers 422, 424, 426 and 428 sandwiched between the substrate cavity bottom surface 452 and a back surface of the diaphragm 415 around the perimeter 145 of cavity 440, similar to reflector 444.
In other embodiments, of resonators 400, 480 and 490, the perimeter walls of cavity 440 may be angled outward from cavity top surface 452 to plate back surface 412 instead of vertical as shown in the figures. In these cases, the Si sidewalls of the cavity will have an angle and the layers of the Bragg reflectors 454, 484 and 494 will be stacked, such as by being deposited over the angled sidewalls. This approach has a benefit of having direct bonding of the plate to the Si substrate material at the perimeter of the cavities and/or in the areas between multiple XBARs formed on a single chip, which is good for not forming electrical parasitics with RF filter pads on top of the resonator that form connections to external circuitry. In some sense this arrangement is more desirable than the blanket layers of Bragg reflector material layers 422, 424, 426 and/or 428 sandwiched between the substrate cavity bottom surface 452 and a back surface of the diaphragm 415 around the perimeter 145 of cavity 440.
In some cases, instead of tungsten and SiO2 layers, the resonators 400, 480 and 490, may use a different conductive metal for the W and/or a different dielectric for the SiO2.
The three series resonators 510A, B, C and the two shunt resonators 520A, B of the filter 500 are formed on a single plate 410 of piezoelectric material bonded to a silicon substrate (not visible). Each resonator includes a respective IDT (not shown), with at least the fingers of the IDT disposed over a cavity in the substrate. In this and similar contexts, the term “respective” means “relating things each to each”, which is to say with a one-to-one correspondence. In
Each of the resonators 510A, 510B, 510C, 520A, 520B in the filter 500 has resonance where the admittance of the resonator is very high and an anti-resonance where the admittance of the resonator is very low. The resonance and anti-resonance occur at a resonance frequency and an anti-resonance frequency, respectively, which may be the same or different for the various resonators in the filter 500. In over-simplified terms, each resonator can be considered a short-circuit at its resonance frequency and an open circuit at its anti-resonance frequency. The input-output transfer function will be near zero at the resonance frequencies of the shunt resonators and at the anti-resonance frequencies of the series resonators. In a typical filter, the resonance frequencies of the shunt resonators are positioned below the lower edge of the filter's passband and the anti-resonance frequencies of the series resonators are position above the upper edge of the passband.
In some cases, the pedestals further provide a path for thermal cooling of the XBAR in combination with thick IDT electrodes or busbars (e.g., that may be used in high power XBARs). This may be an important part or benefit of the XBARs with SMR pedestals herein. For example, two benefits of the pedestals may be to provide mechanical support for the very thin diaphragm and to provide a thermally conductive path for heat to flow from the diaphragm and IDT electrodes to the substrate 120, 320 or 420.
Description of Methods
The piezoelectric plate at 602 may be as described herein. Thin plates of single-crystal piezoelectric materials may be bonded to a non-piezoelectric substrate. The piezoelectric plate may be, for example, Z-cut, rotated Z-cut, or rotated Y-cut lithium niobate or lithium tantalate. In some cases, it is Y-cut or rotated Y-cut lithium niobate. The piezoelectric plate may be some other material and/or some other cut. Both lithium niobate and lithium tantalate plates may be bonded to various substrates including silicon, quartz, and fused silica.
The substrate 604 may be silicon (as used in the previous examples) fused silica, quartz, or some other material. The substrate may be some other material that allows formation of deep cavities by etching or other processing.
At 620 an acoustic Bragg reflector, such as reflector 154, 354, 454, 484 or 494, is formed by depositing alternating layers of high acoustic impedance and low acoustic impedance materials. At 620, some or all of the layers of the acoustic Bragg reflector may be deposited on the bottom surface of the piezoelectric plate that is on the sacrificial substrate 602, on a bottom surface of a cavity in substrate 604 and/or as blanket layers on a top surface of the device substrate 604. After depositing some or all layers of the reflector, the pedestals of the reflector are formed. The layers of the Bragg reflector and pedestals may be formed at 620 as noted for any of
At 630, the piezoelectric plate on the sacrificial substrate 602 and the device substrate 604 may be bonded such that the layers of the acoustic Bragg reflector are sandwiched between the piezoelectric plate and the device substrate. The plate may be attached to or mounted onto the substrate so that the back surface of the piezoelectric diaphragm is attached to or bonded to the top surfaces of the pedestals, and the top surfaces of the pedestals are opposite locations on the plate where some or all interleaved fingers of the IDT will be formed at step 650.
The piezoelectric plate on the sacrificial substrate 602 and the device substrate 604 may be bonded using a wafer bonding process such as direct bonding, surface-activated or plasma-activated bonding, electrostatic bonding, or some other bonding technique. Note that, when one or more layers of the acoustic Bragg reflector are deposited on both the piezoelectric plate and the device substrate, the bonding will occur between or within layers of the acoustic Bragg reflector.
After the piezoelectric plate on the sacrificial substrate 602 and the device substrate 604 may be bonded, the sacrificial substrate, and any intervening layers, are removed at 640 to expose the surface of the piezoelectric plate (the surface that previously faced the sacrificial substrate). The sacrificial substrate may be removed, for example, by material-dependent wet or dry etching or some other process.
In some cases, at 630 the Bragg reflector layers are deposited and the pedestals are etched out through sequential selective etching of a few layers, using the same lithography. After pedestals are formed the LN plate with sacrificial Si substrate is bonded to the pedestals thus forming air cavities between the pedestals. Then, the end sacrificial Si substrate is etched away leaving the LN membrane fixed on the pedestals and standing over the air cavities.
In other cases, at 630 a few layers of the Bragg reflector are deposited on the LN plate with sacrificial Si substrate. Then the layers of the pedestal portion of the Bragg reflector are subsequently etched through a lithography mask, down to the LN plate. The formed pedestals together with the LN/Si base are then bonded over a Si substrate having blanked formed the mirror portion layers of the Bragg reflector on top of the Si substrate prior to bonding. The sacrificial Si substrate is then etched away so that a LN membrane is formed over air gaps between the pedestals.
Both of the examples above can also be performed using a lift-off process to remove areas of the pedestal portion between the pedestals instead of etching through lithography mask.
A variation of the process 600, the layers of the acoustic Bragg reflector are deposited on a surface of another substrate or a reflector substrate to be mounted to the bottom of substrate 604 so the reflector is located within a back side etched cavity. The reflector substrate may be mounted onto substrate 604 prior to or after mounting the plate on the top of the substrate 604. In either case, the back surface of the piezoelectric diaphragm is attached to or bonded to the top surfaces of the pedestals, and the top surfaces of the pedestals are opposite locations on the plate where some or all interleaved fingers of the IDT will be formed at step 650. The layers of the Bragg reflector and pedestals may be formed in this variation as noted for
A conductor pattern, including IDTs of each XBAR, is formed at 650 by depositing and patterning one or more conductor layer on the surface of the piezoelectric plate that was exposed when the sacrificial substrate was removed at 640. The conductor pattern may be, for example, aluminum, an aluminum alloy, copper, a copper alloy, or some other conductive metal. Optionally, one or more layers of other materials may be disposed below (i.e. between the conductor layer and the piezoelectric plate) and/or on top of the conductor layer. For example, a thin film of titanium, chrome, or other metal may be used to improve the adhesion between the conductor layer and the piezoelectric plate. A conduction enhancement layer of gold, aluminum, copper or other higher conductivity metal may be formed over portions of the conductor pattern (for example the IDT bus bars and interconnections between the IDTs).
The conductor pattern may be formed at 650 by depositing the conductor layer and, optionally, one or more other metal layers in sequence over the surface of the piezoelectric plate. The excess metal may then be removed by etching through patterned photoresist. The conductor layer can be etched, for example, by plasma etching, reactive ion etching, wet chemical etching, and other etching techniques.
Alternatively, the conductor pattern may be formed at 650 using a lift-off process. Photoresist may be deposited over the piezoelectric plate. and patterned to define the conductor pattern. The conductor layer and, optionally, one or more other layers may be deposited in sequence over the surface of the piezoelectric plate. The photoresist may then be removed, which removes the excess material, leaving the conductor pattern.
Forming the conductor pattern at 650 includes forming fingers of the pattern at finger locations such that the top surfaces of the pedestals of the Bragg reflector are opposite some or all interleaved fingers of the IDT.
At 660, one or more optional front-side dielectric layers may be formed by depositing one or more layers of dielectric material on the front side of the piezoelectric plate. The one or more dielectric layers may be deposited using a conventional deposition technique such as sputtering, evaporation, or chemical vapor deposition. The one or more dielectric layers may be deposited over the entire surface of the piezoelectric plate, including on top of the conductor pattern. Alternatively, one or more lithography processes (using photomasks) may be used to limit the deposition of the dielectric layers to selected areas of the piezoelectric plate, such as only between the interleaved fingers of the IDTs. Masks may also be used to allow deposition of different thicknesses of dielectric materials on different portions of the piezoelectric plate.
After the conductor pattern and optional front-side dielectric layer are formed at 650 and 660, the filter device may be completed at 670. Actions that may occur at 670 including depositing and patterning additional metal layers to form conductors other than the IDT conductor pattern; depositing an encapsulation/passivation layer such as SiO2 or Si3O4 over all or a portion of the device; forming bonding pads or solder bumps or other means for making connection between the device and external circuitry; excising individual devices from a wafer containing multiple devices; other packaging steps; and testing. Another action that may occur at 670 is to tune the resonant frequencies of the resonators within the device by adding or removing metal or dielectric material from the front side of the device. After the filter device is completed, the process ends at 695.
A variation of the process 600 starts with a single-crystal piezoelectric wafer at 602 instead of a thin piezoelectric plate on a sacrificial substrate of a different material. Ions are implanted to a controlled depth beneath a surface of the piezoelectric wafer (not shown in
Closing Comments
Throughout this description, the embodiments and examples shown should be considered as exemplars, rather than limitations on the apparatus and procedures disclosed or claimed. Although many of the examples presented herein involve specific combinations of method acts or system elements, it should be understood that those acts and those elements may be combined in other ways to accomplish the same objectives. With regard to flowcharts, additional and fewer steps may be taken, and the steps as shown may be combined or further refined to achieve the methods described herein. Acts, elements and features discussed only in connection with one embodiment are not intended to be excluded from a similar role in other embodiments.
As used herein, the pair of terms “top” and “bottom” can be interchanged with the pair “front” and “back”. As used herein, “plurality” means two or more. As used herein, a “set” of items may include one or more of such items. As used herein, whether in the written description or the claims, the terms “comprising”, “including”, “carrying”, “having”, “containing”, “involving”, and the like are to be understood to be open-ended, i.e., to mean including but not limited to. Only the transitional phrases “consisting of” and “consisting essentially of”, respectively, are closed or semi-closed transitional phrases with respect to claims. Use of ordinal terms such as “first”, “second”, “third”, etc., in the claims to modify a claim element does not by itself connote any priority, precedence, or order of one claim element over another or the temporal order in which acts of a method are performed, but are used merely as labels to distinguish one claim element having a certain name from another element having a same name (but for use of the ordinal term) to distinguish the claim elements. As used herein, “and/or” means that the listed items are alternatives, but the alternatives also include any combination of the listed items.
The patent claims priority to co-pending U.S. provisional patent application 63/169,874, filed Apr. 2, 2021, entitled XBARS WITH SMR PEDESTALS.
| Number | Date | Country | |
|---|---|---|---|
| 63169874 | Apr 2021 | US |
